Lippert-components LCI Electronic/Hydraulic Leveling & Slideout Bedienungsanleitung Seite 1

Rev: 07.14.2014Page 1Untitled-1LCI ELECTRONIC/HYDRAULIC LEVELING � SLIDEOUTOWNER'S MANUAL

Rev: 07.14.2014Page 10Untitled-1Manual Leveling ProcedureNOTE: When leveling your coach, the coach should be leveled from FRONT TO REAR first (steps 2

Rev: 07.14.2014Page 11Untitled-1Fig. 9Fig. 10Manual Override for Bi-Rotational Power Units1. Remove protective label (Fig. 9A).2. Manually open jack

Rev: 07.14.2014Page 12Untitled-1Callout Part # DescriptionA 157505 Fill CapB 141610 Extend/Retract Fitting (90° elbow)C 141087 Extend/Retract Fitting

Rev: 07.14.2014Page 13Untitled-1AABBFig. 11 - P/N 149086Fig. 12 - P/N 149085EEFFGGHHManual OverrideManual OverrideDCIIBJJDC

Rev: 07.14.2014Page 14Untitled-1AABFig. 13 - P/N 149083Fig. 14 - P/N 149084EEFFGGHHManual OverrideManual OverrideDCIIBDCJJ

Rev: 07.14.2014Page 15Untitled-1Fig.15 - P/N 149087Fig. 16- P/N 145941AAEEFFGGHHManual OverrideManual OverrideIICCBBDDJJ

Rev: 07.14.2014Page 16Untitled-1Fig. 17 - P/N 179866AEFGHManual OverrideIBBJ

Rev: 07.14.2014Page 17Untitled-1Wire Color FunctionWhite 12v DC PowerWhite w/ Black Pump RetractBlue Curbside Rear ValveGreen Roadside Front ValveYell

Rev: 07.14.2014Page 18Untitled-1Clockwise for manual overrideCounter-clockwise for normal operationFig. 19 - Unidirectional Fig. 20- UnidirectionalMan

Rev: 07.14.2014Page 19Untitled-1Fig. 22 Fig. 23Fig. 21Run drill in reverse or counterclockwise to retract.Plastic Cap (A)5. Insert driver into couple

Rev: 07.14.2014Page 2Untitled-1TABLE OF CONTENTSSystem 3System Description 3Component Description 4LCI Hydraulic Jacks 4Steel Jacks - Bi-rotation

Rev: 07.14.2014Page 20Untitled-1Callout Part # DescriptionA 141109 Extend/Retract Fitting (Straight)B 156846 Extend/Retract Fitting (90° Elbow)C 14108

Rev: 07.14.2014Page 21Untitled-1Fig. 24 - P/N 196894Fig. 25 - P/N 197248KFManual OverrideGHDCJJKIFManual OverrideHGDAEAIEB

Rev: 07.14.2014Page 22Untitled-1Fig. 26 - P/N 211166Fig. 27 - P/N 196895EAFIKJHDAGManual OverrideHKFAAIDGManual OverrideEJ

Rev: 07.14.2014Page 23Untitled-1Fig. 28 - P/N 197247Fig. 29 - P/N 197249FKHIJAADGManual OverrideEGDHIAJKFAEManual Override

Rev: 07.14.2014Page 24Untitled-1Fig. 30 - P/N 218311HKManual OverrideFEGCBBAD

Rev: 07.14.2014Page 25Untitled-1Wire Color FunctionWhite 12v DC PowerWhite w/ Black Pump RetractBlue Curbside Rear ValveGreen Roadside Front ValveYell

Rev: 07.14.2014Page 26Untitled-1Automatic Safety Shutoff If the control panel is left on and inactive for four minutes it will shut off automatically.

Rev: 07.14.2014Page 27Untitled-1MaintenancePreventative Maintenance Procedures1. Change fluid in reservoir only every 36 months.A. Check fluid only

Rev: 07.14.2014Page 28Untitled-1Slideout Adjustment2"-3" Free TravelAdjusting room so it seals in the "IN" position1. Locate cyli

Rev: 07.14.2014Page 29Untitled-1Problem Probable Cause Corrective ActionSystem will not turn on and on/off indicator light does not illuminate.Coach i

Rev: 07.14.2014Page 3Untitled-1SystemFailure to act in accordance with the following may result in death or serious personal injury.The use of the Lip

Rev: 07.14.2014Page 30Untitled-1Troubleshooting Chart - HLGProblem Probable Cause Corrective ActionJacks will not extend to ground, pump is running.Li

Rev: 07.14.2014Page 31Untitled-1The contents of this manual are proprietary and copyright protected by Lippert Components, Inc. (“LCI”). LCI prohibit

Rev: 07.14.2014Page 4Untitled-1Part # 175176 CAPACITY - 12,000 lb.STROKE - 15 in.H - 19 1/2 in. D - 2 3/8 in.9” SHOE-STANDARD12” SHOE-OPTION

Rev: 07.14.2014Page 5Untitled-1Leveling System ControlsLeveling Features• Automatic extension of jacks from full retract position (with automatic gro

Rev: 07.14.2014Page 6Untitled-1Callout DescriptionA Manual Operation - Places control panel in manual operation mode.B Manual Operation LED - Indicate

Rev: 07.14.2014Page 7Untitled-1Level Zero Point CalibrationBefore auto-leveling features are available, the Level Zero point must be set. This is the

Rev: 07.14.2014Page 8Untitled-1Air and Auxiliary Feature ConfigurationFor Diesel Units with Airbag Suspensions ONLY:• Feature is entered ONLY after z

Rev: 07.14.2014Page 9Untitled-1Prior to OperationThe leveling system should only be operated under the following conditions:1. The coach is parked on